Simple Answers from Dr. Dan's Auto: Engine Air FilterMay 22nd, 2014
What's the harm in putting off replacing my engine air filter a little longer?
Dr. Dan's Auto Answer:
That's a fair question from blackwood drivers because the harm takes a while to manifest. Let's take a small step back and talk about what an engine air filter does.
The air all around us contains dust, dirt, pollen, spores, etc. Some areas and times of the year have more contaminants in the air. The job of the air filter is to keep that stuff out of your engine. The benefit to blackwood drivers is obvious.
Now your engine uses a lot of air – like 12,000 times the volume of air as fuel – so the engine air filter has job to do. When the filter gets full and can't hold any more dirt, all that air still has to get to the engine so dirt gets forced through the filter and heads on downstream.
The air flows passed the mass air flow (MAF) sensor on its way to the engine. The MAF sensor tells the engine control computer how much air is coming so the computer can send the proper amount of fuel into the engine to maintain the correct air-to-fuel ratio.
When dirty air is flowing passed the filter, dirt starts to build up on the delicate MAF sensor elements, causing incorrect air flow readings. The computer then sends the wrong amount of fuel to the engine. This can rob power from the engine. But the harm comes from unburned fuel passing out through the exhaust system and getting caught in the catalytic converter, leading to damage.
A primary cause of catalytic converter failure is improper engine management, often triggered by a dirty MAF sensor which was contaminated because the engine air filter had not been replaced as recommended. Now blackwood drivers can buy several cases of engine air filters for what it would cost to replace a catalytic converter. So when it's time to replace your engine filter, keep in mind the potential long term effects of putting it off. Talk to your friendly and knowledgeable Dr. Dan's Auto service advisor.
Give us a call.
Dr. Dan's Auto
850n blackhorse pike
blackwood, NJ 08012